Want to get rid of the ads? Become a member by registering today.
The Mariah Owners Club

Forum Left Top

Welcome to the The Mariah Owners Club.


erratic revs

Mercury MerCruiser

Reply
 
Thread Tools
Old 06-19-2018, 09:46 AM   #1

Lewy is currently offline
Posts: 38
Status: First Mate
Join Date: Jan 2013
Location: Shepperton UK
My Year: 1999
My Model: 182
My Engine: 4.3L mercriuser
Gallery Images: 0


Thanks: 7
Thanked 0 Times in 0 Posts
Send Lewy:
a Private Message
 
Default erratic revs

anyone suggest an issue with my 4.3L?
basically starts fine and sometimes revs nicely in all throttle positions in and out of gear. Usually at some point though the revs will start dropping and sometimes rising without my input.
When in gear i will have to almost pop it out of gear to and rev the engine to overcome the issue. Even when idling with a warm engine it will behave, and then suddenly drop down to just above 500rpm instead of around 800 rpm. Last season it was fine and this issue has only occurred in the last few weeks when boat was launched for the first time.
Just to add i removed and checked the plugs and they all looked good. Also took the distributor cap off and cleaned up the terminals as there was a small amount of corrosion.

Any advice?

Cheers guys

Lewy
Reply With Quote
  • Old 06-14-2020, 02:24 PM   #2

    Lewy is currently offline
    Posts: 38
    Status: First Mate
    Join Date: Jan 2013
    Location: Shepperton UK
    My Year: 1999
    My Model: 182
    My Engine: 4.3L mercriuser
    Gallery Images: 0


    Thanks: 7
    Thanked 0 Times in 0 Posts
    Send Lewy:
    a Private Message
     
    Default Re: erratic revs

    Just to add i discovered the issue, and it was a loose cable on the battery. Tightened it up properly and that seemed to resolve the issue.......for the time being
    Reply With Quote
    Old 06-14-2020, 02:26 PM   #3

    Lewy is currently offline
    Posts: 38
    Status: First Mate
    Join Date: Jan 2013
    Location: Shepperton UK
    My Year: 1999
    My Model: 182
    My Engine: 4.3L mercriuser
    Gallery Images: 0


    Thanks: 7
    Thanked 0 Times in 0 Posts
    Send Lewy:
    a Private Message
     
    Default Re: erratic revs

    Just to add 2 years on it happened again yesterday! It might be an earthing issue with a faulty or corroded cable. On the 182 model does anyone know where all the earth terminals are?
    Reply With Quote
    Old 06-14-2020, 03:23 PM   #4

    mikeyt is currently offline
    Posts: 7,475
    Status: Platinum Contributor
    Join Date: Jul 2007
    Location: Ontario
    Find me on the Map
    My Year: 1996
    My Model: Shabah 180
    My Engine: 4.3
    Gallery Images: 14


    Thanks: 87
    Thanked 579 Times in 538 Posts
    Send mikeyt:
    a Private Message
     
    Default Re: erratic revs

    I believe most of the ground cables are located on the inside of the stern just behind the battery. At least that is where mine is. Here's a quick & easy wiring diagram from 1996 that would still be applicable for your boat;
    Attached Files
    File Type: pdf 1996 wiring diagrams.pdf (181.8 KB, 4 views)
    Reply With Quote
    Old 06-15-2020, 08:37 AM   #5

    Lewy is currently offline
    Posts: 38
    Status: First Mate
    Join Date: Jan 2013
    Location: Shepperton UK
    My Year: 1999
    My Model: 182
    My Engine: 4.3L mercriuser
    Gallery Images: 0


    Thanks: 7
    Thanked 0 Times in 0 Posts
    Send Lewy:
    a Private Message
     
    Default Re: erratic revs

    thanks Mikey, very useful.
    Are there earth points on the engine too, do you think?
    Mines a mercruiser 4.3L
    Forgive my ignorance on these matters.....
    Reply With Quote
    Old 06-15-2020, 12:35 PM   #6
     
    Hudson River Steve's Avatar

    Hudson River Steve is currently offline
    Posts: 596
    Status: Platinum Contributor
    Join Date: Jun 2010
    Location: Lower Hudson Valley
    Find me on the Map
    My Year: 1999
    My Model: Z280
    My Engine: 7.4L MPI Bravo3
    Gallery Images: 5


    Thanks: 1
    Thanked 90 Times in 87 Posts
    Send Hudson River Steve:
    a Private Message
     
    Default Re: erratic revs

    Merc typically installs studs on each side of the bell housing on the rear of the engine block. Just follow the large gauge black wires from the battery.

    Sent from my SM-N975U using Tapatalk
    __________________
    Hudson River Steve
    1999 Z280
    7.4 MPI, Bravo3
    Reply With Quote
    Old 06-16-2020, 11:35 AM   #7

    Lewy is currently offline
    Posts: 38
    Status: First Mate
    Join Date: Jan 2013
    Location: Shepperton UK
    My Year: 1999
    My Model: 182
    My Engine: 4.3L mercriuser
    Gallery Images: 0


    Thanks: 7
    Thanked 0 Times in 0 Posts
    Send Lewy:
    a Private Message
     
    Default Re: erratic revs

    Thanks Steve, i'll check those too.
    is it possible the battery isolator switch might also cause issues?
    I say that because i had one day of faultless engine issues to the next time erratic behavior again.
    The only thing in between was turning the battery switch off and on again....
    thanks for the help
    Reply With Quote
    Reply

    Bookmarks




    Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
     
    Thread Tools


    Similar Threads
    Thread Thread Starter Forum Replies Last Post
    New Owner/ Erratic trim indicator tcjr88 Introductions 6 06-17-2013 08:51 PM
    engine just revs when in gear zzzino1 Mercury MerCruiser 7 09-16-2012 11:06 PM
    Top end revs on a 5.7 EFI / B1 DGR-Z246-98 Prop Talk 14 05-04-2009 03:17 PM
    Uneven low revs? DGR-Z246-98 Original Mariah Talk 1 12-30-2008 12:41 AM



    Forum Right Top
    Forum Left Bottom Forum Right Bottom
     
    Right Left
    Member Login
    Forgot password?
    Forum LeftForum Right

    About the Club
    Age of the Mariah Owners Club:

    Total Members: 18,511
    Total Threads: 12,950
    Total Posts: 68,294
    Find us on Facebook Follow us on Twitter Subscribe to Mariah Owners Club on YouTube
    There are 154 users
    currently browsing forums.
    Forum LeftForum Right

    Find us on Facebook
    Forum LeftForum Right

    Club Sponsors
    Right Sponsor





    Forum LeftForum Right
    Right Right
    Right Bottom Left Right Bottom Right